4H-SiC TSOB结势垒肖特基二极管静态特性

摘要/Abstract

摘要：

为增强器件的反向耐压能力,降低器件的漏电功耗,采用Silvaco TCAD对沟槽底部具有SiO₂间隔的结势垒肖特基二极管(TSOB)的器件特性进行了仿真研究。通过优化参数来改善导通压降(V_F)-反向漏电流(I_R)和击穿电压的折衷关系。室温下,沟槽深度为2.2 μm时,器件的击穿电压达到1 610 V。正向导通压降为2.1 V,在V_F=3 V时正向电流密度为199 A/cm²。为进一步改善器件的反向阻断特性,在P型多晶硅掺杂的有源区生成一层SiO₂来优化漂移区电场分布,此时改善的器件结构在维持正向导通压降2.1 V的前提下,击穿电压达到1 821 V,增加了13%。在1 000 V反向偏置电压下,反向漏电流密度比普通结构降低了87%,有效降低了器件的漏电功耗。普通器件结构的开/关电流比为2.6×10³(1 V/-500 V),而改善的结构为1.3×10⁴(1 V/-500 V)。

关键词: 结势垒肖特基二极管, 导通压降, 击穿电压, 反向漏电流

Abstract:

Trench type schottky rectifier with oxide mass in trench bottom (TSOB) is simulated with Silvaco TCAD to enhance the reverse blocking capability and leakage current power.For improving the forward voltage drop (VF)-reverse current density (IR) trade-off and the breakdown voltage are simulated and optimized.The breakdown voltage of TSOB is 1 610 V and the forward voltage drop is 2.1 V at 300K.In order to improve the device characteristics,oxide mass is injected into the trench of TSOB.The breakdown voltage is 1 821 V,which is about 13% more than that of the TSOB.The reverse current density is reduced by 87% compared to the TSOB without sacrificing the forward voltage drop at reverse bias of 1 000 V.In addition,the optimized structure has a on/off current ratio of 1.3×10⁴ (1 V/-500 V),whereas the TSOB exhibits a ratio of 2.6×10³(1 V/-500 V).

Key words: junction barrier schottky rectifier;forward voltage drop;breakdown voltage;reverse leakage current

中图分类号:

TN387.5

苗志坤,李天琪,徐立坤. 4H-SiC TSOB结势垒肖特基二极管静态特性[J]. , 2013, 26(8): 26-.

MIAO Zhikun,LI Tianqi,XU Likun. Study on the Static Characteristics of 4H-SiC TSOB Junction Barrier Schottky Rectifiers[J]. , 2013, 26(8): 26-.

参考文献

［1］CHOW T P.High-voltage SiC and GaN power devices［J］.Microelectronic Engineering,2006,83(1):112-122.

［2］MUNISH V,ASHOKE K C.Recent trends in silicon carbide device research［J］.Mj.Int.J.Sci.Tech.2008,2(3):444-470.

［3］LIN Z,CHOW T P.Analytical modeling of high-voltage 4H-SiC Junction Barrier Schottky (JBS) rectifiers［J］.IEEE Transactions on Electron Devices,2008,55(8):1857-1863.

［4］HULL B A,SUMAKERIS J J,M J O′Loughlin,et al.Performance and stability of large-area 4H-SiC 10-kV junction barrier schottky rectifiers［J］.IEEE Transactions on Electron Devices,2008,55(8):1864-1870.

［5］KOEL A,RANG T,RANG G.Complementary multi guard ring JBS structures:numerical analysis［C］.IEEE 2010 12th Biennial Baltic Electronics Conference,2010:85-88.

［6］CHEN F P,ZHANG Y M,ZHANG Y M,et al.Edge termination study and fabrication of a 4H-SiC Junction Barrier Schottky Diode［J］.Chin.Phys.B,2011,20(11):117301-1-117301-5.

［7］HESAM M,ANKAN D,et al.Design comparison of high power medium-voltage converters based on 6.5 kV Si-IGBT/Si-PiN diode,6.5 kV Si-IGBT/SiC-JBS diode,and 10kV SiC MOSFET/SiC-JBS diode［J］.IEEE Transaction on Electron Devices,2011,58(6):2421-2428.

［8］HUANG X,WANG G Y,LEE W M,et al.Reliability of 4H-SiC SBD/JBS Diodes under Repetitive Surge Current Stress［J］.IEEE Transaction on Electronic Devices,2012,59(8):2245-2248.

［9］BANU V,GODIGNON P,et al.Enhanced power cycling capability of SiC Schottky diodes using press pack contacts［J］.Microelectronics Reliability,2012(11):1-6.

［10］CARMELO S.ROSSANO C.Trench type schottky rectifier with oxide mass in trench bottom［P］.USA:Patent Application Publication,US,0210401 A1,2007.

［11］CHEN F P,ZHANG Y M,LU H L,et al.Fabrication and characteristics of a 4H-SiC junction barrier Schottky diode［J］.Journal of Semiconductors,2011,32(6):064003-064003.

［12］TIAN S.Monte Carlo simulation of ion implantation in crystalline SiC with arbitrary polytypes［J］.IEEE Transactions on Electron Devices,2008,55(8):1991-1996.

［13］HATAKEYAMA T,WATANABE T,SHINOHE T.Impact ionization coefficients of 4H silicon carbide［J］.Applied Physics Letters,2004,85(8):375-376.

［14］STESZEWSKI J,JAKUBOWSKI A.Comparison of 4H-SiC and 6H-SiC MOSFET I-V characteristics simulated with Silvaco Atlas and Crosslight Apsys［J］.Journal of Telecommunication Information Technology,2007(3):93-95.

［15］MAHAJAN A,SKROMME B J.Design and optimization of junction termination extension (JTE) for 4H-SiC high voltage Schottky diodes［J］.Solid-state Electronics,2005,49(6):945-955.

［16］TADAYOSHI D,TOSHIKATAU K,MANABU A,et al.High On/Off Current Ratio p-InGaN/AlGaN/GaN HEMTs［J］.IEEE Electron Device Letter,2012,33(9):1249-125.

[1]	张飞,林茂,毛鸿凯,苏芳文,隋金池. 一种具有N埋层的AlGaN/GaN高电子迁移率晶体管[J]. 电子科技, 2021, 34(5): 61-65.
[2]	苏芳文,毛鸿凯,隋金池,林茂,张飞. 一种低功耗4H-SiC IGBT的仿真研究[J]. 电子科技, 2021, 34(1): 31-36.
[3]	毛鸿凯, 苏芳文, 林茂, 张飞, 隋金池. 一种具有低寿命区的阳极短路4H-SiC IGBT仿真研究[J]. 电子科技, 2021, 34(1): 60-64.
[4]	孙友磊,唐健翔,王颖,黄意飞,王文举. 一种阳极连接P型埋层的AlGaN/GaN肖特基二极管[J]. 电子科技, 2020, 33(1): 51-56.
[5]	王富强,马行空,瞿宜斌. 3 A/40 V新型肖特基势垒二极管的设计与研制[J]. , 2016, 29(3): 134-.