一种开关磁阻电机模糊PI的直接瞬时转矩控制

doi:10.16180/j.cnki.issn1007-7820.2019.11.012

Abstract

Abstract:

Noise is a big problem for switched reluctance motor. Aiming at the problem of large torque ripple in the operation of switched reluctance motor, the motor model obtained by finite element calculation was used to conduct the fuzzy PI direct instantaneous torque control of switched reluctance motor in MATLAB simulation. The Ansoft electromagnetic field simulation software was adopted to establish a three-phase 4/6 switched reluctance motor, and the obtained flux linkage data was introduced into the MATLAB motor model. Subsequently, a Simulink simulation experimental platform with a fuzzy PI direct instantaneous torque control was set up by the obtained model. Simulation results showed the system started to respond at 0.01 s and the torque was floating between 0.05~0.1 Nom. Therefore, the application of the motor model obtained by finite element to the simulation experiment of fuzzy PI direct instantaneous torque control could improve the system response and effectively suppressed the torque ripple.

Key words: switched reluctance motor, torque pulsation, finite element method, MATLAB, fuzzy PI, direct instantaneous torque, Ansoft

CLC Number:

TP273

ZHAO Hui,JIN Hai. Direct Instantaneous Torque Control of Switched Reluctance Motor Based on Fuzzy Self-tuning PI[J].Electronic Science and Technology, 2019, 32(11): 58-63.

Figures/Tables 19

Table 1

Figure 1.

Figure 2.

Figure 3.

Figure 4.

Figure 5.

Figure 6.

Figure 7.

Figure 8.

Figure 9.

Figure 10.

Figure 11.

Figure 12.

Figure 13.

Figure 14.

Figure 15.

Figure 16.

Figure 17.

Figure 18.

References 20

[1]	Wenju Yan, Hao Chen, Tong Xu , et al. An improved simulation model of switched reluctance motor including transient corelosses forsteady-stateoperation[J]. COMPEL the International Journal for Computation and Mathematicsin Electrical and Electronic Engineering, 2019,38(1):477-499
[2]	孔彦召, 张向龙 . 基于有限元法的开关磁阻电机建模及验证[J]. 黑龙江电力, 2018,40(5):420-423.
	Kong Yanzhao, Zhang Xianglong . Modeling and verification of switched reluctance motor based on finite element method[J]. Heilongjiang Electric Power, 2018,40(5):420-423.
[3]	李红伟, 唐学建, 陈佩斯 , 等. 一种开关磁阻电机复合模糊自整定PI控制器设计[J].控制与信息技术, 2019(1):27-31,38.
	Li Hongwei, Tang Xuejian, Chen Peisi , et al. Design of a composite fuzzy self-tuning PI controller for SRM[J]. Control and Information Technology, 2019(1):27-31,38.
[4]	李存贺, 王国峰, 李岩 , 等. 开关磁阻电机直接自适应神经网络控制[J]. 电机与控制学报, 2018,22(1):29-36.
	Li Cunhe, Wang Guofeng, Li Yan , et al. Direct adaptive neural network control of switched reluctance motors[J]. Electric Machines and Control, 2018,22(1):29-36.
[5]	霍东亮, 邓福军 . 基于模糊控制开关磁阻电机直接转矩系统研究[J]. 微电机, 2018,51(6):54-58,62.
	Huo Dongliang, Deng Fujun . Research on direct torque system of switched reluctance motor based on fuzzy control[J]. Micromotors, 2018,51(6):54-58,62.
[6]	刘灏颖, 李红伟, 邓刚 , 等. 开关磁阻电机模糊滑模转速控制[J]. 电气自动化, 2014,36(5):18-19,70.
	Liu Haoying, Li Hongwei, Deng Gang , et al. Speed control of switched reluctance motors through fuzzy sliding mode control[J]. Electrical Automation, 2014,36(5):18-19,70.
[7]	姚璋, 陈树明 . 开关磁阻电机发展及转矩脉动抑制策略研究[J]. 科技创新导报, 2019,16(4):121-124.
	Yao Zhang, Chen Shuming . Research on the development of switched reluctance motor and torque ripple suppression strategy[J]. Science and Technology Innovation Herald, 2019,16(4):121-124.
[8]	赵玉成, 郑宝周, 顿文涛 , 等. 基于ANSYS Workbench的开关磁阻电机定子振动分析[J]. 河南农业大学学报, 2018,52(3):366-370.
	Zhao Yucheng, Zheng Baozhou, Dun Wentao , et al. Vibration analysis of the stator of SRM based on ANSYS Workbench[J]. Journal of Henan Agricultural University, 2018,52(3):366-370.
[9]	栾茹, 郭金茹 . 基于ANSYS的开关磁阻电机负载振动仿真研究[J]. 系统仿真学报, 2017,29(11):2760-2766,2773.
	Luan Ru, Guo Jinru . Simulation on switch reluctance motor vibration under load condition[J]. Journal of System Simulation, 2017,29(11):2760-2766,2773.
[10]	刘成尧, 潘再平 . 基于三相逆变器驱动开关磁阻电机的DITC调速系统设计[J]. 电机与控制应用, 2016,43(6):39-44.
	Liu Chengyao, Pan Zaiping . Research of SRM DITC control system based on three-phase inverter[J]. Electric Machines & Control Application, 2016,43(6):39-44.
[11]	秦晓飞, 戴志兰 . 开关磁阻电机DITC策略优化[J]. 电力电子技术, 2017,51(3):86-88.
	Qin Xiaofei, Dai Zhilan . The optimization simulation of switched reluctance motor DITC strategy[J]. Power Electronics, 2017,51(3):86-88.
[12]	王勉华, 黄富烽 . 基于非线性建模的开关磁阻电机DTC系统研究[J]. 电气传动, 2014,44(4):6-9.
	Wang Mianhua, Huang Fufeng . Research on DTC method for switched reluctance motor with nonlinear modeling[J]. Electric Drive, 2014,44(4):6-9.
[13]	张炳力, 戚永武, 徐国胜 . 开关磁阻电机直接瞬时转矩控制的优化研究[J]. 电子测量与仪器学报, 2014,28(6):591-596.
	Zhang Bingli, Qi Yongwu, Xu Guosheng . Optimization research on direct instantaneous torque control of switched reluctance motor[J]. Journal of Electronic Measurement and Instrumentation, 2014,28(6):591-596.
[14]	於天浩, 吴国庆, 茅靖峰 , 等. 基于滑模控制的SRM直接瞬时转矩控制研究[J]. 微特电机, 2017,45(12):77-80.
	Yu Tianhao, Wu Guoqing, Mao Jingfeng , et al. The SRM direct instantaneous torque control research based on sliding mode control[J]. Small & Special Electrical Machines, 2017,45(12):77-80.
[15]	颜宁, 曹鑫, 邓智泉 . 基于全桥变换器的开关磁阻电机直接转矩控制[J]. 中国电机工程学报, 2018,38(S1):235-242.
	Yan Ning, Cao Xin, Deng Zhiquan . Direct torque control of switched reluctance motors based on full-bridge converter[J]. Proceedings of the CSEE, 2018,38(S1):235-242.
[16]	党选举, 彭慧敏, 姜辉 , 等. 基于模糊分数阶PID的开关磁阻电机直接瞬时转矩控制[J]. 振动与冲击, 2018,37(23):104-110.
	Dang Xuanju, Peng Huimin, Jiang Hui , et al. Direct instantaneous torque control of a switched reluctance motor based on fuzzy fractional order PID[J]. Journal of Vibration and Shock, 2018,37(23):104-110.
[17]	魏肖, 潘松峰, 劳聪聪 . 基于模糊PI的开关磁阻电机调速系统的建模与仿真[J]. 工业控制计算机, 2015,28(9):63-64.
	Wei Xiao, Pan Songfeng, Lao Congcong . Model and simulation of switched reluctance motor speed control system based on fuzzy PI control[J]. Industrial Control Computer, 2015,28(9):63-64.
[18]	李锋, 刘芬, 王宝忠 . 基于模糊PI控制的开关磁阻电机调速系统的MATLAB仿真[J]. 电子设计工程, 2015,23(8):114-117,121.
	Li Feng, Liu Fen, Wang Baozhong . MATLAB simulation of switched reluctance motor speed control system based on fuzzy PI control[J]. Electronic Design Engineering, 2015,23(8):114-117,121.
[19]	王喜莲, 许振亮 . 基于PI参数自适应的开关磁阻电机调速控制研究[J]. 中国电机工程学报, 2015,35(16):4215-4223.
	Wang Xilian, Xu Zhenliang . Speed regulation control of switched reluctance motors based on PI parameter self-adaptation[J]. Proceedings of the CSEE, 2015,35(16):4215-4223.
[20]	蒋泽浩 . 变论域模糊PID控制算法在开关磁阻电机中的应用[J]. 电子设计工程, 2017,25(13):174-177.
	Jiang Zehao . Application of variable universe fuzzy PID control algorithm in switched reluctance motor[J]. Electronic Design Engineering, 2017,25(13):174-177.

参数	尺寸	参数	尺寸
定子外径	144 mm	定子轭高	10 mm
转子外径	72 mm	转子轭高	13 mm
铁心叠长	86.4 mm	轴径	22.8 mm
气隙	0.4 mm	定子槽深	25.6 mm
第二气隙	12 mm	额定转速	3 000 rad·min^-1
定子极弧	32	定子极数	6
转子极弧	30	转子极数	4

Direct Instantaneous Torque Control of Switched Reluctance Motor Based on Fuzzy Self-tuning PI

RichHTML

PDF (PC)

Like

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 19

References 20

Related Articles 15

Metrics

Comments

Recommended 10

[1]	LIU Jianlong,HAO Zhenghang. Comparative Study of Wind Power System Simulation Based on Back-to-Back Converters [J]. Electronic Science and Technology, 2022, 35(2): 67-73.
[2]	LIU Chenmin,WANG Yagang. Optimization of Firefly Algorithm Based on Continuous Space [J]. Electronic Science and Technology, 2022, 35(2): 40-45.
[3]	NIU Shuaichen,WANG Fuzhong,HAN Yaofei,HE Guofeng,NIU Yeke. Control Strategy of Modular Multilevel Converter Under Unbalanced Grid Voltage [J]. Electronic Science and Technology, 2022, 35(1): 80-86.
[4]	WANG Yang,WANG Yagang. Identification Method Based on Step Response and Genetic Algorithm to Optimize Higher-Order Plus Time-Delay Model [J]. Electronic Science and Technology, 2021, 34(9): 41-46.
[5]	LI Yudong,LIAN Haishan,HU Xiaodan. AC/AC Frequency Conversion Power Supply Based on Three-Phase Input [J]. Electronic Science and Technology, 2021, 34(9): 47-53.
[6]	YAN Zhenbin,ZHENG Bochao,ZHOU Zhiyong. Research on Grid Connection of Photovoltaic Power Generation Systems Based on a New Robust Droop Control Method [J]. Electronic Science and Technology, 2021, 34(8): 79-86.
[7]	LIU Yaze,ZHANG Shuai,GUO Liang,CHEN Xintong,WU Jiankang. Simulation Analysis of Induced Current Density of Transcranial Magnetic-Acoustical Electrical Stimulation Based on Realistic Human Head Model [J]. Electronic Science and Technology, 2021, 34(6): 17-22.
[8]	FANG Xin,WU Yaohui,SONG He. Electromagnetic Simulation Analysis of Asynchronous Motor Starting [J]. Electronic Science and Technology, 2021, 34(6): 61-66.
[9]	HE Qiang,YANG Qinghui,ZHANG Huaiwu. A Control Method of Power up Bias Sequence of Radio Frequency Amplifier [J]. Electronic Science and Technology, 2021, 34(2): 1-6.
[10]	SUN Huixia,ZHOU Shangnan,ZHOU Ling,DOU Yongmei. Development of Digital Signal Processing Simulation Platform Based on MATLAB GUI [J]. Electronic Science and Technology, 2021, 34(2): 74-78.
[11]	JIANG Kaiwen,JIN Hai,XU Shen. Design and Simulation of High Power Factor PMSM without Electrolytic Capacitor [J]. Electronic Science and Technology, 2021, 34(12): 13-18.
[12]	CHEN Shengli,WANG Xinzhang,XU Xiaozhuo. Electromagnetic Simulation Analysis of Permanent Magnet Synchronous Motor Demagnetization Fault [J]. Electronic Science and Technology, 2021, 34(10): 32-37.
[13]	SAN Hongjun, LI Pengyu, CHEN Jiupeng, HU Qiongqiong, LI Qi, ZHANG Kaixiang, WANG Chen. A Design and Optimization Analysis of the Centered Positioning Mechanism [J]. Electronic Science and Technology, 2021, 34(1): 10-16.
[14]	WANG Jiaren,WANG Yagang. Research on Complex Control Algorithms for Non-Minimum Phase Systems [J]. Electronic Science and Technology, 2021, 34(1): 55-59.
[15]	HU Xiaodan,LI Yudong,LIAN Haishan. Plugged AC/AC Frequency Conversion System Supply Based on dSPACE [J]. Electronic Science and Technology, 2020, 33(7): 51-56.